Abstract
Background: Sunscreen products aim to help protect the skin against UV radiation and consequently reduce the risk of early skin ageing and skin cancer. However, it is well known that some sunscreen ingredients are not photostable, but this usually refers to irradiation with UV light. Moreover, it has to be mentioned that a relative cumulative erythema effectiveness compliant light source is used for the in vivo sun protection factor (SPF) testing. Here, UV simulators equipped with a xenon arc lamp use filters such as WG320 and UG11 (thickness 1 mm) to minimize infrared (IR) radiation and wavelength below 300 nm. However, under practical conditions, the sunscreen product is not only exposed to UVA/B light, but also to visible light (VIS) and IR light. In fact, the spectrum of solar radiation is composed of approximately 7% UV, 39% VIS and 54% IR. Aims: To investigate the influence of short-wave and long-wave radiation on the photostability of sunscreens. Methods: Irradiation was performed with the Suntest CPS+ that is considered to closely imitate solar radiation. The filter UG11 (thickness 1 mm), which absorbs much of the VIS and IR light, and the glass filter WG320 (thickness 2 mm), which effectively absorbs radiation of wavelengths less than 300 nm, were used in the Suntest CPS+ both individually and in combination and were inserted between the light source and the samples. The following transmission measurements were carried out with Labsphere’s UV-2000s device. Here, the effectiveness (percentage change of SPF before irradiation to SPF after irradiation) as a measure of the photostability was calculated. Results: As expected after total solar spectrum irradiation, the effectiveness in all tested sunscreens is lower compared to relative cumulative erythema effectiveness light used for in vitro testing of SPF. In the reference sunscreen formula S2 as well as in the two different sunscreen products, especially long-wave radiation (>400 nm) had an effect on photostability, whereas short-wave radiation had only a minor impact. In contrast, in the BASF sun care gel line only short-wave radiation below 300 nm had an effect on photostability, and blocking VIS and IR light had no effect at all. Conclusion: Based on these data, we can conclude that short waves and/or VIS + IR light have an influence on the photostability of sunscreens.
